I figure that Cal Rogers (above) was feeling pretty confident on the morning of Saturday, 23 September, 1911. True, Cal Rogers gave the air of always being pretty confident. But this morning in particular he had received word that one of his competitors, Jimmy Ward, had dropped out of the “Hearst Coast-to-Coast Race” after crashing (yet again!) 5 miles outside of Addison, New York. Cal already knew that his other competitor, Bob Fowler had failed on his third attempt to get over the Sierra Nevada Mountains, finally cracking up near the summit, and reducing his Wright Flyer to kindling and canvas. That left just himself, Cal Rogers, the six foot four inch deaf adventurer from Pittsburgh in the running for the $50,000.00 first place prize.
Of course, Cal still had to get to California. He was barely a tenth of the way across the continent now, and he had already crashed three times. He was already decorated with bandages from all the scrapes and scratches he had suffered. The problem was that Cal had been a pilot for all of four months. He had less than 60 hours of flying experience. He knew nothing about navigation by air, and there was no one to teach him. The longest flight so far in the United States had been one from St. Louis to New York City, completed just the month before, by somebody else. In short, Cal was at the very edge of human experience in flight, both physically and mechanically.
The Wright engine (above) on his “Vin Fiz Flyer" had no throttle. The engine was either on or off, at full power or at zero. The pilot had only one way to alter his speed, and that was to “advance the spark”, meaning to alter the instant in the compression cycle when the spark plug fired. In a modern internal combustion engine of the 1920's this would be controlled mechanically. But in the Wright engine of 1911 it was done by physically unscrewing the spark plug a fraction of an inch into or out of the cylinder by hand. The engines' designer and builder, Charlie Taylor, had taken a leave of absence from the Wright workshop in Ohio to accompany the "Vin Fiz Flyer" across the country, and with all the other pressing redesigns required on the engine, this was the best one for advancing the spark that Charlie had come with so far. But it have its own problems which would soon become evident to both Cal and Charlie Taylor..
It took two days to repair the Vin Fiz after the crash at Middletown, New York on 17 September. So Cal did not return to the race until the 21 September, 1911. His first leg that day was to be a hop to Hancock, New York, 40 miles east of Binghamton. But half way there Cal noticed his radiator had sprung a leak. He kept an eye on the precious fluid dripping out of his engine and then, just as he was over the town, pop! A spark plug flew out of engine. Unscrewing the plug to adjust the spark had also made it prone to vibrating itself right out of the engine. In an instant, the 4 cylinder Wright engine lost 25% of its power, and the plane had precious little to spare. Cal suddenly found himself plummeting for the ground. Cal managed to steer for an open field, pulling the "Vin Fiz's" nose up at just the last second to make a cash landing. But it was still a crash. Again, there was nothing to do but wait for the his service train, the "Vin Fiz Special".
The next two weeks would prove to be difficult, as California receded farther and farther away in distance and in time. While making a normal landing at Binghamton, as Cal would later say, “…There was a snap of breaking timber and my right skid had gone". The broken skid was easily replaced over night, from the supplies carried on board the “Vin Fiz Special”, the three car train that followed and led Cal across the country. It carried fuel and a rolling repair shop, and in the Pullman sleeping car, Cal’s wife Mable, and his mother Maude (nee Rodgers) Sweitzer - for the time being.
Maude's second husband, Henrey Sweitzer, had filed for divorce in July, charging Maude with "cruel and barbarous treatment and indignities...and desertion without cause". Henrey might as well have charged Cal at the co-respondent in the divorce, since it seemed Maude had abandoned her wealthy second husband for her son....her married son. Also sleeping on board "The Vin Fiz Special" was plane's chief mechanic Charley Tailor, his second mechanic, Charles (Wiggie) Wiggen, three assistant mechanics and assorted newspaper reporters and photographers.
With such generous support, Cal was airborne again on the morning of 22 September. But as Cal approached a landing at Elmira, New York that afternoon he snagged some telegraph wires. More repairs were required. As Cal traversed the border lands between Pennsylvania and western New York State, he hit a patch of good weather and made up time, at least until late in the afternoon of 24 September. Just after Cal had taken off from Salamanca, New York, high up on the Allegheny River, .another spark plug vibrated its way out of the Wright engine. But this time Cal coolly reached behind his back, grabbed the hot plug in his glove just before it popped completely out. He screwed it back into the engine and held it in place as he made a perfect landing (with one hand) on the Allegheny Indian reservation outside of Red House, N.Y.
Cal now screwed the spark plug firmly back in and, with help of a couple of native Americans, turned the plane around for take off. But he couldn’t work up enough speed and had to abort. He tried again, but the second attempt also had to be aborted. Each time the two helpful locals had tried to warn Cal that he was aiming at a barbed wire fence. But either because he didn’t understand what they were saying (he was deaf,) or because he was in such a rush, Cal ignored their warnings and the third time proved to be the charm. Cal taxied directly into the barbed wire fence, ripping the fabric covering the right wing to shreds, and wrapping the prickly barbed wire around the frame. It would take two days to free the “Vin Fiz Flyer” to fly yet again.
Cal was back in the air on 27 September , and had safe landings that day and the next. But on 29 September he was grounded by bad weather. Still, 30 September saw him break out of the Alleghenies and enter the flat lands of the old Middle West. The "Vin Fiz" covered 200 miles on 30 September, still 50 miles short of the distance he had intended to average. He would have gone further but a clogged fuel line forced him down late in the day near Akron, Ohio. Cal spent that night fending off curious cows who seemed determined to crush his fragile airplane under their big fat hooves. Or maybe they were just looking to catch a flight to some place more respectful of vegetarians.
On Sunday, October first, Cal stopped at first Mansfield and then Marion, Ohio, before being forced down by another clogged fuel line at Rivare, Indiana, just over the state line. Under threatening skies Cal cleared the fuel line and took off again, only to fly directly into a thunderstorm, the first pilot to ever do so. As lightning snapped around his plane, Cal was the first pilot to experience downdrafts and wind shear, and as quickly as he could, Cal landed the "Vin Fiz" again, in the tiny Hoosier town of Geneva. As soon as the weather cleared he flew on to Huntington, Indiana, where he was met by an enthusiastic crowd, and was able to spend the night on board the train with his dear Mable. And his dear mother Maria.
The next morning, 2 October, the winds were still gusting and again Cal had a hard time working up speed on his 35 horsepower Wright engine. Just as he felt his skids leave the ground he realized he was heading for a crowd of people.
Cal yanked the stick to the left, passed under telegraph wires, and bounced his left wing off the ground. Cal was thrown out of his seat and scrapped his forehead. The left wing of the “Vin Fizz” was crumpled and folded up. But the “lucky” bottle of soda dangling from the strut was unbroken, yet again. Or so said the Vin Fiz publicity agents. It would take two days to repair the “Vin Fiz”, essentially its third complete rebuild since takeoff.
Finally, in desperation, on 7 October, Cal loaded the “Vin Fiz” aboard his train and moved it to the village of Lansing, Illinois, where he found a fallow field with a wind break. This allowed him to finally take off again. As his journey westward by rail had not moved him closer to Chicago, technically, he had not advanced his position in the race.
Cal Rogers finally reached the air field in Cicero, Illinois, on the west side of Chicago, on the afternoon of 8 October. This was near where, at the air show in Grant Park on the lake shore just two months before, Cal had made his public debut as a pilot. By the rules, Cal now had less than two weeks to fly the remaining 2,000 miles across the Mississippi and the western half of the Untied States, cross the Rocky Mountains and the Sierra Nevada and the desert in between. Cal Rogers was the only man still in the race, but he was running out of time.
- 30 -
Ford was rebuilding the Wright Brothers workshop in Dayton as a memorial, and had hired detectives to track Charlie down. They brought him back to advise and reconstruct the wind tunnel and put the 1903 Flyer back together. In 1941, his work for Ford finished, Charlie quietly went back to California and returned to work in a Defense plant. In 1945 Charlie suffered a heart attack. He was never able to work again. When Orville Wright died in 1948 he left Charlie an annuity in his will of $800 a year. By 1955 inflation had reduced that to a pittance, and when a newspaper reporter found Charlie he was surviving in the charity ward of a Los Angles hospital. 
Immediately the aviation community raised funds, and Charlie was able to spend his last months in a private hospital. He died at the age of 88 in 1956. He is buried in the Folded Wings Mausoleum, in Valhalla Memorial Park, directly under the approach to Burbank Airport runway 15-33.
Charlie Taylor lived for 48 years after he gave up his seat to a young Army Lieutenant. And he never did learn to fly. And that too was typical for Charlie Taylor, the unsung hero of powered flight.
